Toyota Highlander Service Manual: Location

Toyota Highlander Service Manual / Sliding roof/convertible / Sliding roof system / Location

LOCATION

HOW TO PROCEED WITH TROUBLESHOOTING

HINT: Troubleshoot in accordance with the procedures on the following pages.

1 VEHICLE BROUGHT TO WORKSHOP

2 CUSTOMER PROBLEM ANALYSIS

3 PROBLEM SYMPTOM CONFIRMATION

(a) If the symptom does not occur, proceed to A.

(b) If the symptom occurs, proceed to B.

A SYMPTOM SIMULATION

4 PROBLEM SYMPTOM TABLE

5 CIRCUIT INSPECTION

6 IDENTIFICATION OF PROBLEM

7 REPAIR OR REPLACE

8 CONFIRMATION TEST

END

PROBLEM SYMPTOMS TABLE

Symptom	Suspected area
Sliding roof system operates abnormally	Slide roof control switch Slide roof drive gear sub-assy Wire harness
Sliding roof system stops operation halfway. (No foreign materials are trapped in motor assy)	Slide roof control switch Slide roof drive gear sub-assy Wire harness

Terminals of ECU

1. CHECK SLIDING ROOF DRIVE GEAR SUB- ASSY (SLIDING ROOF ECU) (a) Disconnect the sliding roof ECU connector, and check the voltage or continuity of each terminal of the wire harness side connec ...

More about Toyota Highlander:

Transfer case oil seal (4WD)
REPLACEMENT 1. REMOVE ENGINE ASSEMBLY WITH TRANSAXLE (3MZ-FE ENGINE TYPE) (SEE PAGE 14-149 ) 2. REMOVE ENGINE ASSEMBLY WITH TRANSAXLE (2AZ-FE ENGINE TYPE) (SEE PAGE 14-24 ) 3. REMOVE TRANSVERSE ENGINE ENGINE MOUNTING BRACKET (2AZ-FE ENGINE TYPE) (SEE PAGE 31-9 ) 4. REMOVE TRANSFER STIFFENER P ...