Toyota Highlander manuals

Toyota Highlander Service Manual: Front differential oil seal (U151E)

Toyota Highlander Service Manual / Automatic transmission / trans / Front differential oil seal (U151E)

REPLACEMENT

1. REMOVE FRONT WHEELS

2. REMOVE ENGINE UNDER COVER NO.1

3. DRAIN AUTOMATIC TRANSAXLE FLUID

(a) Remove the drain plug, gasket and drain ATF.

(b) Install a new gasket and the drain plug.

Torque: 49 NVm (500 kgfVcm, 36 ftVlbf)

4. REMOVE FRONT DRIVE SHAFT ASSY LH (SEE PAGE 30-21 )

SST 09520-01010, 09520-24010 (09520-32040)

5. REMOVE FRONT DRIVE SHAFT ASSY RH (2WD DRIVE TYPE) (SEE PAGE 30-21 )

6. REMOVE TRANSAXLE HOUSING OIL SEAL

REMOVE TRANSAXLE HOUSING OIL SEAL


(a) Using SST, pull out the oil seal.

SST 09308-00010

7. REMOVE DIFFERENTIAL SIDE BEARING RETAINER OIL SEAL

REMOVE DIFFERENTIAL SIDE BEARING RETAINER OIL SEAL


(a) Using SST, pull out the oil seal.

SST 09308-00010

8. INSTALL TRANSAXLE HOUSING OIL SEAL

INSTALL TRANSAXLE HOUSING OIL SEAL


(a) Using SST and a hammer, drive in a new oil seal.

SST 09316-6001 1 (09316-00011)

Oil seal drive in depth: 0 0.5 mm (0 0.020 in.)

(b) Coat the lip of the oil seal with MP grease.

9. INSTALL DIFFERENTIAL SIDE BEARING RETAINER OIL SEAL

INSTALL DIFFERENTIAL SIDE BEARING RETAINER OIL SEAL


(a) Using SST and a hammer, drive in a new oil seal.

SST 09223-15020, 09950-70010 (09951-07150)

Oil seal drive in depth: 0 0.5 mm (0 0.020 in.)

(b) Coat the lip of the oil seal with MP grease.

10. INSTALL FRONT DRIVE SHAFT ASSY LH (SEE PAGE 30-21 )

11. INSTALL FRONT DRIVE SHAFT ASSY RH (2WD DRIVE TYPE) (SEE PAGE 30-21 )

12. INSTALL FRONT WHEELS

Torque: 103 NVm (1,050 kgfVcm, 76 ftVlbf)

13. ADD AUTOMATIC TRANSAXLE FLUID

14. INSPECT AUTOMATIC TRANSAXLE FLUID (SEE PAGE 40-2 )

15. INSTALL ENGINE UNDER COVER NO.1

16. CHECK ABS SPEED SENSOR SIGNAL (SEE PAGE 05-765 )

Front differential oil seal (U140F)
REPLACEMENT HINT: When replacing the front differential oil seal (LH) or (RH), perform step 1 to 11 or 12 to 21 respectively. 1. REMOVE FRONT WHEELS 2. REMOVE ENGINE UNDER COVER NO.1 3. DRAIN A ...

Front differential oil seal (U151F)
REPLACEMENT HINT: When replacing the front differential oil seal (LH) or (RH), perform step 1 to 11 or 12 to 23 respectively. 1. REMOVE FRONT WHEEL 2. REMOVE ENGINE UNDER COVER NO.1 3. DRAIN AU ...

More about Toyota Highlander:

Rear window wiper and washer
Operating the wiper lever The wiper operation is selected by moving the lever as follows: *1 Or *2 Intermittent window wiper operation *1 Or *2 Normal window wiper operation *1: For u.S.A. *2: For canada Washer/wiper dual operation The wiper will automatically opera ...

В© 2011-2024 Copyright www.tohighlander.com